Penn Garage Doors: springs, openers, tracks and new doors in Penn, Westmoreland County, PA.
When the spring on a garage door gives out, the door does not suddenly get lighter for the opener. It gets heavier. The spring was carrying most of the weight, and now the motor and your arms are expected to do its job. In Penn Township, a lot of these breaks happen in the middle of winter.
Where the spring is and what broke
On most doors in the township the spring is a torsion spring, a tight coil on the steel bar running across the top of the opening. When it breaks you can see a clear gap in the coil. Older doors, especially on detached garages, may instead have long extension springs running along each horizontal track near the ceiling. When one of those breaks it hangs limp or falls.
The usual sign is a sharp bang, followed by an opener that strains, lifts the door a few inches and stops. Leave the door down. Trying to lift a door without a working spring is one of the more common ways people get hurt in a garage.
Why springs fail here
Every spring wears out after a certain number of trips up and down. A standard one is often rated for about 10,000. A family that uses an under-house garage as its main entrance can reach that number sooner than they expect. Winter shortens it further. On a frozen morning the door may be stuck to the slab, the lubricant has thickened, and the spring takes a heavier load than usual at the very moment it starts to work.
How we replace it
We measure the door and the old spring, choose a new one with the correct wire size and length for the weight, and wind it with proper winding bars. Then we disconnect the opener and lift the door by hand to check the balance. If it stays where we leave it halfway up, it is right. On a two-spring door we change the pair, because the survivor has made every trip its partner made and is close behind.
Cost
This site's price table lists a single torsion spring at $185 to $355. Both springs on a two-spring door run $285 to $525. A pair of extension springs runs $150 to $325. The technician confirms the figure before starting.
Longer-lasting options
If the door runs many times a day, ask about a higher-cycle spring. It costs a bit more up front and holds out longer. Call (724) 634-4887 and ask for both prices.
- LiftMaster
- Chamberlain
- Genie
- Clopay
- Amarr
- Wayne Dalton
What Garage Door Spring Repair Costs in Penn
| Job | Typical range |
|---|---|
| Single torsion spring | $185–$355 |
| Two springs, replaced together | $285–$525 |
| Side-mounted springs (pair) | $150–$325 |
Ranges apply in Penn Township and the surrounding Westmoreland County towns, and your technician confirms the exact price at the door before any work.
Related Services
Also in Penn: Emergency Garage Door Repair and Garage Door Cable & Track Repair. See the FAQ or garage door repair in Penn homepage.
Garage Door Spring Repair in Penn, Any Hour
Call (724) 634-4887. The estimate costs nothing.
☎ Call (724) 634-4887Questions About Garage Door Spring Repair
How much is a new garage door spring in Penn Township?
This site's price table lists a single torsion spring at $185 to $355, both springs on a two-spring door at $285 to $525 and a pair of extension springs at $150 to $325.
Why did my spring break in the cold?
Stiff lubricant plus a seal frozen to the floor puts extra load on a spring that was already worn.
Do both springs need replacing?
If your door has two, yes. They are the same age and the second is near the end of its life.
How can I tell the spring is broken?
Look for a gap in the coil on the bar above the door, or a loose spring along the side track.
Is a higher-cycle spring worth it?
If the garage is your main entrance, it usually is, because it lasts longer under heavy use.